Agriculture and Food, Regulatory Services

Rule R70-330

Raw Milk for Retail

Notice of Proposed Rule

(Amendment)

DAR File No.: 36914
Filed: 10/04/2012 09:07:17 AM

RULE ANALYSIS

Purpose of the rule or reason for the change:

The purpose of this amendment is to adjust requirements to conform to statutory provisions.

Summary of the rule or change:

The main amendment is to make raw milk standards and enforcement in the rule to be identical with those in statute. Changes are also proposed to spell out Pasteurized Milk Ordinance rather than refer to it as PMO; to change the somatic cell standard to 400,000 from 350,000 cells per ml.; to eliminate the requirement for an inspection from the Department prior to lifting the suspension of a permit; and allow the sale of stored raw milk batches which meet testing standards.

State statutory or constitutional authorization for this rule:

• Section 4-3-2

Anticipated cost or savings to:

the state budget:

The amendments will remove the requirement for a Department inspection prior to lifting the suspension of a permit. No impact on the state budget has been identified.

local governments:

There will be no effect on budget for local governments since they have no responsibility for raw milk.

small businesses:

Based on information gained from small raw milk producers on 09/13/2012, the changes will reduce their overhead. They did not quantify the impact.

persons other than small businesses, businesses, or local governmental entities:

The Division has included all stakeholders in the preparation of these proposed amendments. No financial impacts have been identified beyond those described above.

Compliance costs for affected persons:

Costs of compliance will be reduced because producers will not have to discard approved milk produced in batches prior to the one that causes a suspension.

Comments by the department head on the fiscal impact the rule may have on businesses:

The proposed amendments which bring the rule's raw milk standards and enforcement provisions are essential. The other changes are based on detailed discussion with the industry, academia and other stakeholders. They should reduce the overhead and compliance costs for small producers without compromising the public health protection.

Leonard M. Blackham, Commissioner

The full text of this rule may be inspected, during regular business hours, at the Division of Administrative Rules, or at:

Agriculture and Food
Regulatory Services
350 N REDWOOD RD
SALT LAKE CITY, UT 84116-3034

Direct questions regarding this rule to:

• Kyle Stephens at the above address, by phone at 801-538-7102, by FAX at 801-538-7126, or by Internet E-mail at kylestephens@utah.gov
• Kathleen Mathews at the above address, by phone at 801-538-7103, by FAX at 801-538-7126, or by Internet E-mail at kmathews@utah.gov
• Richard Clark at the above address, by phone at 801-538-7150, by FAX at 801-538-7126, or by Internet E-mail at richardwclark@utah.gov

Interested persons may present their views on this rule by submitting written comments to the address above no later than 5:00 p.m. on:

12/03/2012

This rule may become effective on:

12/10/2012

Authorized by:

Leonard Blackham, Commissioner

R70. Agriculture and Food, Regulatory Services.

R70-330. Raw Milk for Retail.

R70-330-1. Authority.

A. Promulgated under the authority of Section 4-3-2.

B. Scope: This rule establishes the requirements for the production, distribution, and sale of raw milk for retail.

C. History: The Utah Department of Agriculture and Food, with the concurrence of the U.S. Food and Drug Administration (FDA) strongly advises against the consumption of raw milk. There are numerous documented outbreaks of milkborne disease involving Salmonella and Campylobacter infections directly linked to the consumption of un-pasteurized milk. Cases of raw milk associated campylobacteriosis have been reported in the states of Arizona, California, Colorado, Georgia, Kansas, Maine, Montana, New Mexico, Oregon, Pennsylvania, and Utah. An outbreak of salmonellosis, involving 50 cases was confirmed in Ohio in 2002. Recent cases of Escherichia coli (E. coli) 0157:H7, Listeria monocytogenes, and Yersinia enterocolitica infections have also been attributed to raw milk consumption.

 

R70-330-2. Definitions.

A. "Raw milk" means milk as defined by law that has not been pasteurized, or heat treated. The word milk shall be interpreted to include the normal lacteal secretion, practically free of colostrum, obtained by the complete milking of one or more healthy hoofed mammals.

B. "Properly staffed" means a person or persons on premise available to sell milk, exchange money, and lock and secure the retail store.

C. "Quarterly pathogen testing verification" means a sample from the Raw for Retail batch is aseptically split by the Regulatory agency and tested for the prescribed pathogens at both the independent laboratory and the department laboratory and the results are evaluated and compared.

D. "Department" means the Utah Department of Agriculture and Food.

 

R70-330-3. Permits.

A permit shall be required to sell raw milk for retail. Such permit shall be suspended when these rules or applicable sections of the Utah Dairy Act, Utah Code Annotated (UCA), Vol. 1, Title 4, Chapter 3, are violated. Cow-share programs, as defined in the Utah Dairy Act, shall not be allowed, either in conjunction with a permitted raw for pasteurization dairy, a permitted raw milk for retail dairy, or in lieu of a permit to sell raw milk for retail.

 

R70-330-4. Building and Premises Requirements.

The building and premises requirements at the time of the issuance of a new permit shall be the same as the current Grade A building guidelines. In addition to these guidelines, there shall be separate rooms provided for (1) packaging and sealing of raw milk, (2) the washing of returned multi-use containers when applicable, and (3) a sales room for the sale of raw milk in a properly protected area that is not located in any of the milk handling rooms. These rooms shall meet or exceed the construction standards of a Grade A milkhouse. If the Raw for Retail dairy also raises chickens ,or other poultry, for meat and/or eggs, their housing and movement shall be restricted to areas that do not include the milkhouse, milk barn and their immediate surroundings, the corrals and alleys where there is normally cows or goats, and other locations where there is normal cow or goat traffic. They shall also be restricted from areas normally considered traffic areas of the raw milk customers.

 

R70-330-5. Sanitation and Operating Requirements.

A. Sanitation and operating requirements of all raw milk facilities shall be the same as that required on a Grade A dairy farm producing milk for pasteurization. Milk packaging areas and container washing areas at the raw milk facilities shall meet the requirements for Grade A pasteurized milk processing plants.

B. All milk shall be cooled to 50 degrees F. or less within one hour of the commencement of milking and to 41 degrees F. or less within two hours after the completion of milking.

C. The blend temperature after the first milking and subsequent milkings shall not exceed 50 degrees. Milk not handled in the manner required in this subsection and subsection "B" above shall be deemed adulterated and shall not be sold.

1. All raw for retail farm bulk milk tanks put into use on or after August 7, 2007 shall be equipped with an approved temperature-recording device, in addition to the indicating thermometer. Daily temperature logs shall be maintained for bulk milk tanks in use prior to August 7, 2007.

2. The recording device shall be operated continuously and be maintained in a properly functioning manner. Circular recording charts shall not overlap.

3. The recording device shall be verified as accurate every six (6) months and documented in a manner acceptable to the department.

4. Recording thermometer charts shall be maintained on the premises for a minimum of six (6) months and available to the department.

5. The recording thermometer shall be installed near the milk storage tank and accessible to the department.

6. The recording thermometer shall comply with the current technical specifications in the Pasteurized Milk Ordinance [(PMO)] for tank recording thermometers.

7. The recording thermometer charts shall properly identify the producer, date, and signature of the person removing the chart.

D. The temperature of the milk at the time of bottling shall not exceed 41 degrees F.

E. The sale and delivery of raw milk shall be made on the premise where the milk is produced and packaged, or at a self -[ ]owned, properly staffed, retail store. Sanitation and construction requirements of the facilities used as self[ ] -owned, retail stores shall be the same as those contained in the Wholesome Food Act, Title 4, Chapter 5. Transportation shall be done by the producer with no intervening storage, change of ownership, or loss of physical control. The temperature of the milk shall be maintained at 41 degrees F or below. Each display case shall have a properly calibrated thermometer, and a daily temperature log shall be maintained and made accessible to the Department.

F. Raw milk brick cheese, when held at no less than 35 degrees F. for 60 days or longer, may be sold at retail stores or for wholesale distribution, at locations other than the premise where the milk was produced.

G. Except as provided in part (F) above, all products made from raw milk including, but not limited to, cottage cheese, buttermilk, sour cream, yogurt, heavy whipping cream, half and half, butter, and ice cream shall not be allowed for sale in Utah.

H. Milk that has been heat treated, shall not be labeled as "Raw Milk" for retail sale.

I. Inspections of the self[ ] -owned retail store shall be performed no less than four times per year to insure compliance with the sanitation, construction, and cooling requirements as set forth in the Wholesome Food Act, Title 4, Chapter 5.

 

R70-330-6. Testing.

A. The bacterial standards for unpackaged raw milk, packaged raw milk sold on premise and packaged raw milk sold at a self-owned retail store shall be a bacterial count of no more than 20,000 per ml. and a coliform count of no more than 10 per ml.

B. Raw Milk for Retail Testing.

1. Unpackaged Raw Milk

a. The Department shall collect a representative sample of milk from each Raw for Retail farm bulk tank once each month. All samples shall be delivered to the State Dairy Testing Laboratory. Tests shall include those prescribed for Raw Milk for Pasteurization as found in the Pasteurized Milk Ordinance[PMO], and in addition shall include added water, and/or other adulterants. Whenever a sample result fails to meet a standard in any of the prescribed categories,[ a warning and probation letter shall be issued. The letter shall be prominently displayed at the dairy, so that customers will read it, until the next official sample results are received by the Department. Upon receipt of the official sample results, the dairy shall be taken off of probation or suspended. T] the Raw for Retail permit shall be suspended until satisfactory sample results are received by the Department or a [contracted] approved independent laboratory, meeting Pasteurized Milk Ordinance[PMO]/Department standards and reported to the department by the laboratory[, and until an inspection can be performed at the facility by the Department. All expenses for the re-sampling, re-testing, and re-inspecting shall be born by the producer as per the Department's fee schedule]. At such time as the above criteria are met, the Raw for Retail permit shall be fully reinstated.

b. The [standards for testing ]Somatic Cell Count (SCC) in unpackaged raw milk for retail [shall be, the Somatic Cell Count ]shall not exceed 400,000[350,000] cells per milliliter (ml) for cows, and not to exceed [1,000,000]1,500,000 cells per ml for goats. [The requirements for sampling, and the enforcement procedures for SCC shall be the same as those set forth in 1.a. above.]Whenever three out of five samples fail to meet this standard in a 5-month period, the Department shall suspend the raw for retail permit. The suspension shall remain effective until a sample result meets the standard. A temporary permit shall be issued at that time. The permit shall be fully reinstated when three of five samples meet the standard in a five-month period.

[c. The bacterial standards shall be a Standard Plate Count (SPC) of no more than 20,000 per ml. and a coliform count of no more than 10 per ml.

]2. Packaged Raw Milk sold on Premise

a. It shall be the responsibility of the Department to collect a representative sample of packaged raw milk once each month. All samples shall be delivered to the State Dairy Testing Laboratory. Tests shall include those prescribed for Grade "A" Pasteurized milk as found in the Pasteurized Milk Ordinance[PMO]. Whenever a sample result fails to meet a standard in any of the prescribed categories, [a warning and probation letter shall be issued. The letter shall be prominently displayed at the dairy, so that customers will read it, until the next official sample results are received by the Department. Upon receipt of the official sample results, the dairy shall be taken off of probation or suspended. T]the Raw for Retail permit shall be suspended until satisfactory sample results are received by the Department, meeting Pasteurized Milk Ordinance[PMO]/Department standards[, and until an inspection can be performed at the facility by the Department. All expenses for the re-sampling, re-testing, and re-inspecting shall be born by the producer as per the Department's fee schedule]. At such time as the above criteria are met, the Raw for Retail permit shall be fully reinstated.[ When a sample produces a violative Coliform count of more than 10 per mL, the count shall be enumerated and the sample transferred to appropriate laboratory facilities for pathogen testing.]

3. Packaged Raw Milk sold at Self-Owned Retail Stores

a. It shall be the responsibility of the producer to have a [third party ]sampler certified by the Department to collect a sample from each batch of milk delivered to the retail store by obtaining one container of milk at the store and submitting it to the State Dairy Laboratory a certified independent[third party] laboratory to be tested for Antibiotic Drug Residue, Standard Plate Count (SPC) and Coliform Count. All containers of milk from the sampled batch shall be withheld from sale until the results of the tests are known. Whenever a sample result exceeds the standard in any of the prescribed categories,

(i) the producer shall not allow the milk to enter into commerce and shall dispose of the milk in a manner agreeable to the Department, and

(ii) the Department shall suspend the producer's raw for retail permit until satisfactory sample results are received by a contracted approved independent laboratory, meeting Department standards, and reported to the Department by the laboratory. The producer may sell raw milk from batches that were produced earlier and whose testing results met the standards.

b. It shall be the responsibility of the Department to collect at the operator's expense or oversee collection of a representative sample of packaged raw milk once each month for screening for the presence of Listeria monocytogenes, Salmonella, Campylobacter jejuni, and E. Coli 0157:H7. All samples shall be delivered to the State Dairy Testing Laboratory or other laboratories approved by the department. Test results showing any growth or activity shall be considered positive. If any of the screening test results are positive, then a confirmation test shall be performed.

Whenever any of the test results for any the prescribed pathogens are positive, the Raw for Retail permit shall be suspended until such time as a compliant sample can be obtained by the Department or contracted approved independent laboratory, meeting Pasteurized Milk Ordinance[PMO]/Department standards[, and until an inspection can be performed at the facility by the Department]. All expenses for the re-sampling, re-testing, and re-inspecting may[shall] be born e by the producer as per the Department's fee schedule. At such time as the above criteria are met, the Raw for Retail permit shall be fully reinstated.

c. A hazard analysis and critical control point (HACCP) System including a milk testing procedure for specified pathogens shall be required, and approved by the department, for all raw for retail dairies.

d. The HACCP System shall include plans and policies for initiating and conducting a recall in the event of a positive pathogen test result.

e. The HACCP System shall include the seven following principles:

(i) Conduct hazard analysis

(ii) Determine the critical control points

(iii) Establish critical limits

(iv) Establish monitoring procedures

(v) Establish corrective actions

(vi) Establish verification procedures

(vii) Establish record-keeping and documentation procedures.

f. Prior to the implementation of a HACCP plan, develop, document and implement written Prerequisite Programs (PPs). The HACCP Plan, along with the PPs becomes the HACCP System. Steps to producing the HACCP Plan and System are found in the U.S. National Advisory Committee on Microbiological Criteria for Food (NACMCF) document.

g. The HACCP plan shall identify and address points in the production, distribution, transportation and retail display system where the milk may become contaminated or held in conditions that support the growth of pathogens.

(i) When tests are performed by an independent laboratory, quarterly pathogen testing verification shall be conducted by the Department.

(ii) Independent laboratories shall participate in an annual split sampling program testing the capacity of the pathogen methodology directed by this rule, and results sent to the Department.

h. The producer shall recall all milk from the failed batch that is already in commerce.

i. A database shall be kept and made available for review by both the Utah Department of Agriculture and Food and the Utah Department of Health of all customers, which shall include names, addresses, and telephone numbers of customers, dates of purchases and amounts of milk purchased.

j. If another agency's epidemiological investigation finds probable cause to implicate a raw for retail dairy in a milkborne illness outbreak, the Raw for Retail Permit may be suspended by the Department until such time as milk samples are pathogen free when analyzed by the Department or other Department approved testing laboratories, and until an inspection can be performed at the facility by a Compliance Officer from the Department.

B. Animal Health Tests.

1. General herd health examination. Prior to inclusion in a raw milk supply, and each six months thereafter, all animals shall be examined by a veterinarian. Each animal in the herd must be positively identified as an individual. This examination shall include an examination of the milk by a method recommended by the Pasteurized Milk Ordinance[PMO], shall include a statement of the udder health of each animal, and a general systemic health evaluation.

2. Tuberculosis testing. Prior to inclusion in a raw milk supply, each animal shall have been tested for tuberculosis within 60 days prior to the beginning of milk production and shall be retested for tuberculosis once each year thereafter. All positively reacting animals shall be sent to slaughter in accordance with R58-10 and R58-11.

3. Brucellosis testing. Each animal from which raw milk for retail is produced shall be positively identified as a properly vaccinated animal or shall be negative to the official blood test for brucellosis within 30 days prior to the beginning of each lactation. All positively reacting animals shall be sent to slaughter in accordance with R58-10 and R58-11. Goats and sheep shall be tested once each year for brucellosis with the official blood test and all positively reacting animals shall be sent to slaughter in accordance with R58-10 and R58-11.

4. Bulk tank milk testing. All raw milk for retail shall be bulk tank tested at least four times yearly with the brucella milk ring test. If such brucella ring test is positive for brucellosis, then each animal in the herd shall be tested with the official blood test and any reactors found shall be immediately sent to slaughter in accordance with R58-10 and R58-11.

C. Personnel Health.

Each employee of the dairy working in the milk handling operation shall obtain a valid medical examination health card signed by a physician and approved by the department once each year and shall hold a valid food handler's permit. No person shall work in a milk handling operation if infected from any contagious illness or if they have on their hands or arms any exposed infected cut or lesion. If there is any question in this regard, the department may ask for an additional certification from a physician that this person is free from disease which may be transmitted by milk.

 

R70-330-7. Packaging and Labeling.

A. Label Requirements.

The consumer containers for raw milk for retail shall be furnished by the permittee and shall be labeled with the following information:

1. The common or usual name of the product without grade designation. The common name for raw milk is "Raw Milk". If it is other than cow's milk, the word "milk" shall be preceded with the name of the animal, i.e., "Raw Goat Milk".

2. The name, address, and zip code of the place of production and packaging.

3. Proper indication of the volume of the product either on the container itself or on the label.

4. Nutritional labeling information when applicable.

5. The phrase: "Raw milk, no matter how carefully produced, may be unsafe.", shall appear on the label in a conspicuous place. The height of the smallest letter shall be no less than one eighth inch.

6. The phrase: "Keep Refrigerated", shall also appear on the label with the height of the smallest letter no less than one eighth inch.

7. The shelf life labeling of bottled raw milk shall include a pull date, expiration date, or best-if-used-by date, and shall be displayed and clearly visible on raw milk. Raw milk shall not be sold after the pull date, expiration date, or best-if-used-by date has expired, and the date shall not be more than nine days after packaging.

8. Other provisions of labeling laws in effect in Utah relative to dairy/food products also apply. On the primary panel the words "raw" and "milk" shall be the same size lettering.

[9. Glass bottles embossed, printed, or otherwise permanently labeled in accordance with this rule prior to August 7, 2007 and in use on or before August 7, 2007 shall be exempt from R-70-330-7-A(5).

]B. Products not labeled as required shall be deemed misbranded.

 

KEY: dairy inspections , raw milk

Date of Enactment or Last Substantive Amendment: [December 14, 2007]2012

Notice of Continuation: March 16, 2011

Authorizing, and Implemented or Interpreted Law: 4-3-2